All new 2006 to 2013 V6 and V8 engine repair kits! CLICK HERE to view AlL.
A 12 volt test light is a very handy tool to have when working on any car but it is particularly important if you have a old diesel. This tool will allow you to quickly determine if there is power getting to your glow plugs, and if not where the power is breaking down.
When replacing the steering lock assembly in your Benz you will need to remove that little black plastic switch on the side of the lock from the old one and put it on the new part. You can not pry it off, squeeze it off or pull it off by hand.
Tired of lugging around heavy batteries or battery boosters to test electrical components in your car? It does not have to be a Mercedes. It does not even have to be a car. Anything that runs off 12 volt DC power can be tested by these small, light weight but very powerful batteries.
Electric power seats are great if they are working ok. When they do not work - especially in the fore and aft or tilt movement it can be very frustrating to even drive the car.
If your power seat is not working it is hard to determine if it is a switch, a motor under or inside the seat, or a wiring problem. From our experience xx % of the time the problem is in a worn out or failed electrical seat switch.
If your rear door power window is not moving or the motor is not making any noise, it could be a failed motor, rear door switch, front switch or even a wiring problem. Trying to narrow down the problem can be frustrating unless you know the proper troubleshooting sequence.
THESE ARE GENUINE BOSCH. Do not purchase the cheaper aftermarket regulators as we have found they do not last. This voltage regulator that bolts on to the back of your alternator. This is the common failure point and when it does you will not be getting any charge to your battery.
If your engine temperature gauge is not reading at all, you need to fix it before you keep driving the car. To ignore this could lead to major engine failure, since you will have no way to get an adequate warning that your engine is about to overheat.
New voltage regulator to fit the following 201 and 124 models listed below from 1990 to 1995. No instructions included but not difficult to replace.
Fits the following
1992 and 1993 190E 2.3 ONLY (Does NOT fit 2.6 models!)
1990 to 1995
Buy a spare to carry in your trunk! FITS THE FOLLOWING: Late 107 and 116, 123, 126 up through 1991 and 201 and 124 chassis to through 1989. ALSO FITS 1990-1993 300D 2.5 AND 92-93 190E 2.6 ONLY!
Yes, there may be a fuse inside or outside your fuse box that controls your heater blower motor or another high amp draw electrical component. Most of the separate fuse holders require a 30 amp fuse. You may find a funny looking bent fuse inside your fuse box.
Fits chassis 116 123 126 124 and 201 Diesels with pencil glow plugs, from 1978 to 1989. This includes the OM617, OM601, OM602, and OM603 engines. They also work on 1977 to 1979 300D 300CD and 300TD with series glow plugs. This pack includes three individual fuses.
To many people, automotive electrical systems and testing are a big mystery. It is not as complicated as you might think.
When an old Mercedes ( or any other car for that matter ) has sat idle for over a year it can be a challenge to get it safely back on the road again. If it has sat idle for more than 5 years you may find it difficult to even get the engine running.
Malfunctioning and failed power window regulators (mechanisms) are so common on older Mercedes that Kent can almost guarantee if you own one and drive it regularly you will have to fix one at some point.
The power window is stuck closed. Do the tests outlined in this video first. You may have to remove the regulator and to do that; you have to lower the window. But how???
This is part 8 of Kent's 8-part video series on servicing and repairing the power sunroofs on the 1980 to 1985 W123, W126, and W201.
This is part 7 of Kent's 8-part video series on servicing and repairing the power sunroofs on the 1980 to 1985 W123, W126, and W201. This video will cover ONLY those issues related to the sunroof round motor drive assembly.
These will no longer be printed when these are gone. They will still be available as a download. All books are signed by Kent. This is an end of an era for us. Most books are approximately 15 pages in length and covered with heavy clear plastic.
Often rotten and torn. Replace with new when working on your fuel delivery system. PLEASE NOTE: These are included when you purchase any of our fuel pump delivery kits.
To many people, automotive electrical systems and testing are a big mystery. It is not as complicated as you might think.
This 17-minute video will cover the removal of an old Hirschmann power antenna and then Kent will show you how to troubleshoot the wiring plug in the car to see if you are getting proper power back to the antenna. No sense in replacing a faulty antenna until you make sure your wiring is OK!
When the motor won't move the window down you can not get to the bolts that hold the regulator to the glass. So then how can you get it out of the door! What a pain! In this xxx minute video Kent will show you what you need to do in order to get a "stuck" power window regulator out of a door.
Fuses, supplies, and video instructions (below) to restore most older fuse boxes to better than original condition.
Fuses, supplies, tools and video instructions (below) to restore most older fuse boxes to better than original condition.
This is a must-have if you have a prized Benz or any car you don't drive often!! If you let any of your cars sit for long periods ( generally over 30 days) without driving them, you can ruin your battery, especially if you let it go completely dead.
In this video instruction Kent will show you how he installs our battery tender kit in a W124 Mercedes.
After years of "fighting" fuse replacement, Kent finally decided he had had enough! And so was born another special tool. It is designed to securely grab hold of a ceramic fuse, remove it from it, and replace it with minimal exertion and no damage.
Car alarms have their place, but on 20 year and older cars Kent is not so sure... When they get that old they can get very tempermental and will usually go off when you least expect it and in places that can cause great embarrassment.
Jammed up steering locks and keys that won't turn can leave you stranded.
Kent explains why it is important to to remove and open up the motor assembly anytime you are replacing a damaged cable. On the bench he explains the workings of the motor and transmission and shows close up examples of what each of the different components do.
Tilting power sunroof problems can be many. This is particularly true on roof mechanisms that have not received proper lubrication over the years. One of the first things that can fail is the power sunroof cable.
In this video Kent explains some of the key reasons for poor battery contact and loss of voltage to important electrical components. If you want your later model Mercedes to run a peak performance pay attention to your battery.
Digital PDF instructions for cleaning your pencil glow plug chambers. 5 pages of step by step instructions with detailed pictures to visually assist you in completing the job.
These instructions pertain only to the multi pin plug switch on the back of the ignition lock and key assembly.
Covers 190D 300D 300TD 300SDL 350SD 350SDL 1984 - 1993. Book 4 in our glow plug series explains how to properly remove and replace the glow plugs in the OM 601 602 and 603 diesel engines from 1984 to 1993.
This is a must-have if you have a prized Benz or any car you don't drive often!! If you let any of your cars sit for long periods ( generally over 30 days) without driving them, you can ruin your battery, especially if you let it go completely dead.
Genuine MBZ Part with wiring plug for later models: Please note this buzzer is really for the 1985 and later models. The wiring pigtail is not used on pre-1985 steering locks. The switch itself is the same but for older models you will have to install and leave the pigtail connected.
Includes 1 meter of nylon braided clear windshield washer hose. No instructions included.
CLICK HERE to view the complete windshield washer squirted kit.
This GENUINE MERCEDES switch will work on all 107 chassis 380SL and 560SL 1981 to 1989, all 126 chassis sedans and coupes 1981 to 1991 , all 123 chassis 240D 300D 300CD 300TD from 1980 to 1985, all 201 chassis 190E 2.6 and 190D ( 190E 2.3 up to 1988 ONLY) and all 124 chassis from 1986 to 1993.
Best plugs for your 102 Engine. Yttrium electrodes out perform platinum especially if your engine is burning oil.
This kit fits many models of Mercedes from the late 1970s up into the late 1990s (see list below). Pump problems abound and when you change the pump you are much better off to change the old rubber seal and brittle washer braided hose at the same time.
FITS THE FOLLOWING: 1985 to 1993 W124, W126, and W201 chassis with a 6 cylinder 103 engine. Is your M103 six cylinder engine not running as smoothly as it use to. These wires should be changed at 70,0000 to 80,000 miles for smooth running and peak performance.
Sometimes you need the extra heat! Like when replacing heater motor brushes.